24 hours for you

iron ore waste as coarse aggregate in concrete

Home - iron ore waste as coarse aggregate in concrete

Experimental Study on Iron Ore Tailings and Bottom Ash

the proportion of iron ore wastes generated is likely to increase due to higher demand for iron ore. Moreover, dumping causes loss of valuable land. problems. IOT is waste produced during iron ore produc Fig.1 Iron Ore Tailing of fine aggregate with IOT and bottom ash helps to effectively

Get Price

Effect of iron ore tailing on the properties of concrete

Feb 05, 2015Effect of iron ore tailing on the properties of concrete. The particle of the processing waste can range in size from colloidal size to fairly coarse, gravel size particles (Kachhap, 2010). Itakpe iron ore deposit has a reserve of about 200 million tonnes with an average iron ore content of 36%.

Get Price

ceramic waste as coarse aggregate and quarry dust as fine

AN EXPERIMENTAL WORK ON CRUSHED CERAMIC WASTE Did investigation on ceramic waste and stone dust as aggregate replacement in concrete. The optimum percentage for replacement of stone dust with fine aggregate along with 20% replacement of coarse aggregate by ceramic tiles. 4.4 S. DeepaBalakrishnan., and K. C. Paulose

Get Price

Experimental Study on Heavy Weight Concrete Using

is 7 N/mm2 for 25% replacement of coarse aggregate with hematite stone and that for laterite concrete is 6.16 N/mm2 for 25% replacement of coarse aggregate with laterite stone. V. CONCLUSIONS In this study, experimental studies on replacement of coarse aggregate with heavy weight aggregates on the properties of concrete was investigated.

Get Price
Authors Francis Atta KuranchieAbout Tailings

Analysis of the Utilization of Air-Cooled Blast Furnace

Natural coarse aggregate (NCA) 10 mm 693 693 347 347 Slag coarse aggregate (SCA) 2.510 mm 347 693 347 Superplasticizer (SP) 3.4 1 Vibrated concrete. Table2shows the chemical composition of all constituents. The four major oxide phases that are present in ACBFS are CaO, SiO2, Al2O3, and MgO. These oxides count on approximately 93% of the

Get Price
Published in International Journal of Civil and Structural Engineering 2012Authors Mohammed Nadeem Arun D PofaleAbout Biology Forensic science Biotechnology Mathematics Statistics Toxicology

Use of red mud and iron tailings in self compacting concrete

Aug 21, 2014Use of red mud and iron tailings in self compacting concrete. Recycled materials such as Fly Ash, Red Mud, Silica Fume are used as a partial replacement for Portland cement in concrete and Quarry Dust, used foundry sand, Mine Tailings are some

Get Price

pdf for coconut shell as aggregate laserrushballito

Investigation of Coconut Shell as a Replacement of Coarse Aggregate in Concrete Satish Shinde 1, Ramiz Sayed 2, Keywords sand, cement, coarse aggregate and coconut shell, coarse aggregate. 1. INTRODUCTION Concrete is widely used as construction material for various types of structures due to its durability. For a long time it was. Get price

Get Price

Ore Coarse Crushing Equipment greenrevolution

iron ore waste as coarse aggregate in concrete Solution As a leading global manufacturer of crushing and milling equipment, iron ore crushing plant; Posts Related to iron ore waste as coarse aggregate in concrete. Read more

Get Price

effects of iron ore as fine aggregate supremewheels

If these tailings are segregated properly, both fine and coarse aggregates for concrete can be obtained. Therefore, if the . Study on Utilization of Iron Ore Tailings as Fine Aggregates ijert. increased the strength is also increased but only up to 30% further the strength is decreased.

Get Price

Utilisation of iron ore tailings as aggregates in concrete

Sep 07, 2015Sustainable handling of iron ore tailings is of prime concern to all stakeholders who are into iron ore mining. This study seeks to add value to the tailings by utilising them as a replacement for aggregates in concrete. A concrete mix of grade 40 MPa was prepared in the laboratory with watercement ratio of 0.5. The concrete were cured for 1, 2, 3, 7, 14 and 28 days.

Get Price

Effect of Partial Replacement of Sand by Iron Ore Tailings

The ingredients of concrete are coarse aggregate, fine aggregate, binding material and water. Rapid increase The aggregate size is lesser than 4.75 mm is considered as in construction activities leads to acute shortage of fine aggregate. The physical property of Iron Ore mining of natural sand, iron ore tailings which is the waste Tailings

Get Price

Use of Sinter-Feed Tailings as Aggregate in Production

Use of Sinter-Feed Tailings as Aggregate in Production of Concrete Paving Elements Ayrton V. Costa, Adriana G. Gumieri Brazil holds the world's sixth largest iron ore deposits and is the second largest producer of The suitability of the use of this waste as aggregate for concrete

Get Price
User rating 4.7/5

EFFECT OF USING STEEL SLAG AGGREGATE ON

of concrete, such as chlorides, organic impurities clay and shells 1.1. Slag Waste in Jordan Slag waste is a material resulting from the melting process of iron scrap or iron ore. The slag produced from iron ore is much less that that produced from melting steel scrap. In

Get Price

Mechanical Properties of Concrete Using Steel Slag

coarse aggregates in concrete has no negative effects on the short term properties of hardened concrete. Mohammed Nadeem1, Arun D. Pofale (2012), studied on replacement of coarse and fine aggregate in concrete by slag. Concrete of M20, M30 and M40 grades were considered for a W/C ratio of 0.55, 0.45 and

Get Price

iron ore aggregates in uae ofspescaracolli

Utilisation of iron ore tailings as those of normal concrete made using conventional aggregates. of iron ore tailings as aggregates in concrete. Copper mining. From ore to copper. China Factory Promotion Aggregate Crusher Plant, USA, UAE, South Africa, Australia and Zimbabwe crusher The copper ore powder undergo flotation machine for.

Get Price

Compressive Strength and Durability Studies on

the coarse aggregates in concrete mixes by Dolochar. Tests were also conducted on the concrete testing cubes for 3,7 and 28 During the manufacturing process of reinforcement steel from iron ore, while processing raw ore to spongeiron, some scrap Compressive Strength and Durability Studies on Concrete with Dolochar as Coarse Aggregate ) .

Get Price

Technical Report UDC 669 . 162 . 275 . 2 666 . 972 . 12

(coarse and fine) for concrete began in the 1970s, and coarse slag aggregate was included in the JIS system as JIS A 5011 "Air Cooled Iron Blast Furnace Slag Aggregate for Concrete" in 1977 and fine BF slag aggregate as JIS A 5012 "Water Granulated Iron Blast Fur-nace Slag Aggregate for Concrete" in 1981. Thereafter, the two were unified as JIS A 5011-1 "Slag Aggregate for Concrete, Part 1 Blast

Get Price

CHAPTER 1 COMPONENTS OF CONCRETE

Dry-rodded Unit Weight Dry-rodded unit weight is the mass (weight) of one cubic meter (foot) of dry coarse aggregate that is compacted, by rodding in three equal layers, in a standard container. For any one aggregate, the dry-rodded unit weight varies with the size and gradation.

Get Price

Volume 7, Issue 4, October 2017 Use of Steel Slag in

fine aggregate in concrete mixes. A. Materials 1. Coarse aggregate Limestone normal aggregate of local sources was used in the preparation of all mixes. Gradation of this was obtained following the ASTMC136 standard procedure. It was found to be well graded and within ASTMC33 grading requirements for coarse aggregates of nominal maximum size 25

Get Price

Effects on compressive strength and durability

Coarse Aggregate Coarse Aggregate used is scrap material obtained during manufacturing process of reinforcement steel from iron ore, while processing raw ore to sponge iron .The physical properties of coarse aggregate were investigated in accordance with IS 23861963. Concrete Mix Design

Get Price

Aggregates Geology The Concrete Portal

. Very coarse grained rocks are undesirable because of poor abrasion resistance. Flat, flaky, and elongated pieces are obtained on crushing metamorphic rocks. Such rocks will pose a problem if used as concrete aggregates. Also, some metamorphic rocks show directional properties because of

Get Price

Iron Stone And Coal Count In Mm Aggregate Concrete

use of iron ore as coarse aggregate in concrete making. iron stone and coal count in mm aggregate concrete Jun 29, 2013 use of iron ore as coarse aggregate in concrete making iron stone and coal count in mm aggregate concrete grinding plant For iron ore processor,sand making,coal,concrete, in fractions of 4070 mm, There are, Coarse aggregate use in heavy concrete mineral processing Get Price Project

Get Price

TCG-JSCE Joint Seminar (Sakai)

L. It corresponds to 20% of the total fossil fuel origin CO2 emissions, which is 30.0 billion tones in 2007. Crushed concrete lumps are passed downward between an outer and inner cylinder. Coarse and fine aggregates are produced by separating a drum into small sections with partitions.

Get Price

Effect on compressive and tensile strength of cement

iron ore particles having diameter less than 150 m, hence generally discarded. Utilization of such mineral wealth is main problem in mining industry. This research is interested in use of iron ore tailing as sand in concrete and mortar. The successful utilization of

Get Price

Research Article Experimental Study on the Properties

particles of iron ore tailings are rough and occluded with coarse aggregate, so cohesion increases signi cantly in the tailingmixes.In addition,ironoretailingshavehigherwater absorption than natural sand. erefore, the tailing mixes are weak in terms of liquidity. According to the test on the retention value of slumps for h, the loss of slumps had a

Get Price

Lecture 4. Aggregates Aalto

recycled concrete aggregate (RCA) when consisting primarily of crushed concrete or more general . recycled aggregate (RA) when it contains substantial quantities of materials other than crushed concrete. Currently, only the use of coarse aggregate derived from construction or demolition waste is recommended for use in new concrete construction.

Get Price

Vol. 4, Issue 4, April 2015 Cost Effective Concrete by

left after the extraction and processing of iron ore in the mines to form fine particles less than 4.75mm. Usually, Iron ore dust is treated as a complete waste, and used to fill the low lying areas. Use of Iron ore dust as an alternative to normal aggregates in concrete M. Nadeem et al draws serious attention of researchers and investigators.

Get Price

coarse aggregate from coal mine for concrete

Utilisation of iron ore tailings as aggregates in concrete Cogent Sep 7, 2015 If mine tailings are considered as a partial or complete replacement of .. Use of coal waste as fine aggregates in concrete blocks for paving. recycling concrete crushing coarse aggregates. Shanghai MALU Mining and Construction Machinery Co., Ltd. is

Get Price

Use of red mud and iron tailings in self compacting concrete

Jul 24, 2014Recycled materials such as Fly Ash, Red Mud, Silica Fume are used as a partial replacement for Portland cement in concrete and Quarry Dust, used foundry sand, Mine Tailings are some of the waste

Get Price

mining sand as fine aggregate concrete

Dec 5, 2016 used in concrete as coarse aggregate in combination with . higher than that of concrete with river sand as fine aggregate and marble waste as. Chat Online. The long-time existence of large-scale iron ore mining in Western Australia For the normal concrete, conventional materials such as sand, cement

Get Price

Get a Free Quote

If you are interested in our company or products, welcome to visit our company or local offices; you can also get contact with us through online consulting, demand table submission, e-mails and telephones. Our staff shall wholeheartedly provide product information, application knowledge and good service for you.